Food Establishment Inspection Report
Page 1  of ????????? 
Lake logo Lake County Health Department
and Community Health Center
500 West Winchester Road Suite 102
Libertyville, IL 60048
Establishment
 SUPREMEFRIES AND MORE 		License/Permit #
 011043
Street Address
2109 LEWIS AVE STE C
City/State
 ZION, IL 		ZIP Code
 60099
No. of Risk Factor/Intervention Violations 0
No. of Repeat Risk Factor/Intervention Violations 0
Date 11/09/2023
Time In 12:05 PM
Time Out 12:50 PM
Permit Holder/Person Interviewed/Person In Charge (PIC)
TYRONE DAVIDSON 		Risk Category
Medium
Purpose of Inspection   Routine

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
 Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
 Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
 Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
 Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55 X Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishment: SUPREMEFRIES AND MORE License/Permit #: 011043 Date: 11/09/2023
Water Supply:   Community Non-Community Licensed Non-Community    Waste Water System:   Community On-Site IEPA System
Sanitizer: Temperature Logs in Use:
Location Method Sanitizer Type Concentration (PPM) Heat(F)
3-Compartment Sink Chemical Sanitizer Chlorine 50 0.00
Wiping Cloth Bucket Chemical Sanitizer Chlorine 50 0.00
CFPM Verification (name, expiration date, ID#):
TYRONE DAVIDSON
09/05/2025
19764433 		     
Presentation Type: STANDARD Number Attended: 1
HACCP Discussed HACCP Principle Plan Onsite
2. Determine the CCP Discussed the HACCP principle of Conducting a Hazard Analysis of identifying a potential hazard as microbiological, physical or chemical. Not Applicable

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
CHICKEN/COOK'S LINE COOLER 40.00°F HAMBURGER/COOK'S LINE COOLER 40.00°F CUT FRESH TOMATOES/COOK'S LINE COOLER 41.00°F
CHICKEN/REACH-IN COOLER 38.00°F BEEF/REACH-IN COOLER 38.00°F CHICKEN/REACH-IN FREEZER 0.00°F
FRENCH FRIES/REACH-IN FREEZER 0.00°F BEEF/STEAM TABLE 145.00°F CHEESE STICKS/STEAM TABLE 143.00°F
           

OBSERVATIONS AND CORRECTIVE ACTIONS
P=Priority      PF=Priority Foundation      C=Core      R=Repeat
Item
Number 		P/PF/C/R Code Reference Violations cited in this report must be corrected within the time frames below.
49 C 4-601.11 (C) Nonfood-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
The inside bottom of the 2-door reach-in cooler and the sides of the cooking equipment are soiled.
Complete detailed cleaning and sanitizing of the item(s) as required.
CORRECT BY NEXT ROUTINE INSPECTION
55 C 6-501.12 (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
the floor in kitchen area is soiled mostly under and behind equipment.
Repair the floors, walls or ceilings to be smooth and easily cleanable.
CORRECT BY NEXT ROUTINE INSPECTION
55 C 6-501.114 The PREMISES shall be free of: (A) Items that are unnecessary to the operation or maintenance of the establishment such as EQUIPMENT that is nonfunctional or no longer used; and (B) Litter.
Unused items and equipment are being stored in the facility.
The premises shall be free of items that are unnecessary to the operation or maintenance of the establishment.
CORRECT BY NEXT ROUTINE INSPECTION
TYRONE DAVIDSON
Person In Charge (Signature)  		Jorge Alvarez
Inspector 
Follow-up:  Yes   No   Follow-up Date: